liu.seSök publikationer i DiVA
Ändra sökning
RefereraExporteraLänk till posten
Permanent länk

Direktlänk
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • oxford
  • Annat format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annat språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf
Strain-free, single-phase metastable Ti0.38Al0.62N alloys with high hardness: metal-ion energy vs. momentum effects during film growth by hybrid high-power pulsed/dc magnetron cosputtering
Linköpings universitet, Institutionen för fysik, kemi och biologi, Tunnfilmsfysik. Linköpings universitet, Tekniska högskolan.ORCID-id: 0000-0002-4898-5115
Linköpings universitet, Institutionen för fysik, kemi och biologi, Tunnfilmsfysik. Linköpings universitet, Tekniska högskolan.
Linköpings universitet, Institutionen för fysik, kemi och biologi, Tunnfilmsfysik. Linköpings universitet, Tekniska högskolan.
Linköpings universitet, Institutionen för fysik, kemi och biologi, Tunnfilmsfysik. Linköpings universitet, Tekniska högskolan.
Visa övriga samt affilieringar
2014 (Engelska)Ingår i: Thin Solid Films, ISSN 0040-6090, E-ISSN 1879-2731, Vol. 556, s. 87-98Artikel i tidskrift (Refereegranskat) Published
Abstract [en]

A hybrid deposition process consisting of reactive high-power pulsed and dc magnetron cosputtering (HIPIMS and DCMS) from Ti and Al targets is used to grow Ti1-xAlxN alloys, with x similar to 0.6, on Si(001) at 500 degrees C. Two series of films are deposited in which the energy and momentum of metal ions incident at the growing film are individually varied. In both sets of experiments, a negative bias V-s ranging from 20 to 280 V is applied to the substrate in synchronous, as determined by in-situ mass spectrometry, with the metal-ion-rich part of the HIPIMS pulse. Ion momentum is varied by switching the HIPIMS and dc power supplies to change the mass m and average charge of the primary metal ion. Al-HIPIMS/Ti-DCMS layers grown under Al+ (m(Al) = 26.98 amu) bombardment with 20 less than= V-s less than= 160 V are single-phase NaCl-structure alloys, while films deposited with V-s greater than 160 V are two-phase, cubic plus wurtzite. The corresponding critical average metal-ion momentum transfer per deposited atom for phase separation is less than p(d)*greater than greater than= 135 [eV-amu](1/2). In distinct contrast, layers deposited in the Ti-HIPIMS/Al-DCMS configuration with Ti+/Ti2+ (m(Ti) = 47.88 amu) ion irradiation are two-phase even with the lowest bias, V-s = 20 V, for which less than p(d)*greater than greater than 135 [eV-amu](1/2). Precipitation of wurtzite-structure AlN is primarily determined by the average metal-ion momentum transfer to the growing film, rather than by the deposited metal-ion energy. Ti-HIPIMS/Al-DCMS layers grown with V-s= 20 V are two-phase with compressive stress sigma= -2 GPa which increases to -6.2 GPa at V-s= 120 V; hardness H values range from 17.5 to 27 GPa and are directly correlated with sigma. However, for Al-HIPIMS/Ti-DCMS, the relatively low mass and single charge of the Al+ ion permits tuning properties of metastable cubic Ti0.38Al0.62 N by adjusting V-s to vary, for example, the hardness from 12 to 31 GPa while maintaining sigma similar to 0.

Ort, förlag, år, upplaga, sidor
Elsevier , 2014. Vol. 556, s. 87-98
Nyckelord [en]
High power impulse magnetron sputtering; High-power pulsed magnetron sputtering; Titanium aluminium nitride; Ionized physical vapor deposition; Magnetron sputtering
Nationell ämneskategori
Teknik och teknologier
Identifikatorer
URN: urn:nbn:se:liu:diva-106133DOI: 10.1016/j.tsf.2014.01.017ISI: 000333085700015OAI: oai:DiVA.org:liu-106133DiVA, id: diva2:714032
Tillgänglig från: 2014-04-25 Skapad: 2014-04-24 Senast uppdaterad: 2017-12-05

Open Access i DiVA

Fulltext saknas i DiVA

Övriga länkar

Förlagets fulltext

Personposter BETA

Greczynski, GrzegorzLu, JunJensen, JensPetrov, IvanGreene, Joseph EHultman, Lars

Sök vidare i DiVA

Av författaren/redaktören
Greczynski, GrzegorzLu, JunJensen, JensPetrov, IvanGreene, Joseph EHultman, Lars
Av organisationen
TunnfilmsfysikTekniska högskolan
I samma tidskrift
Thin Solid Films
Teknik och teknologier

Sök vidare utanför DiVA

GoogleGoogle Scholar

doi
urn-nbn

Altmetricpoäng

doi
urn-nbn
Totalt: 343 träffar
RefereraExporteraLänk till posten
Permanent länk

Direktlänk
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • oxford
  • Annat format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annat språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf